Low fuel pressure resolved! (finally)

MTTod

Registered User
Was only getting 20 PSI at the rail. Changed filter, replaced regulator no diff. Pulled tank today to change fuel pump. Could barely blow through line and only got a little trickle out of return line.

Followed fuel lines from tank. Right where they turn and go up into the front fender well there's a plastic cover. All 3 lines were smashed flat under the cover. You couldn't see it until you pulled the cover off. The small one (purge line?) was actually cut in half.

So I spent a lot of time pulling the tank but it was ok. The seal around the pump/sender unit was leaking pretty bad. I'm going to replace the pump too just in case.

I'm just really glad to finally figure out what the hell was wrong! Can't wait to see how she runs once I get it back together.
 
Back
Top